An Instantaneous Flow Meter Module

FENG Jian; ZHU Min

doi:10.12338/j.issn.2096-9015.2020.0427

Volume 65 Issue 8

Aug. 2021

Turn off MathJax

Article Contents

Article Navigation > Metrology Science and Technology > 2021 > 65(8): 29-32

FENG Jian, ZHU Min. An Instantaneous Flow Meter Module[J]. Metrology Science and Technology, 2021, 65(8): 29-32. doi: 10.12338/j.issn.2096-9015.2020.0427

Citation:

FENG Jian, ZHU Min. An Instantaneous Flow Meter Module[J]. Metrology Science and Technology, 2021, 65(8): 29-32. doi: 10.12338/j.issn.2096-9015.2020.0427

FENG Jian, ZHU Min. An Instantaneous Flow Meter Module[J]. Metrology Science and Technology, 2021, 65(8): 29-32. doi: 10.12338/j.issn.2096-9015.2020.0427

Citation:

FENG Jian, ZHU Min. An Instantaneous Flow Meter Module[J]. Metrology Science and Technology, 2021, 65(8): 29-32. doi: 10.12338/j.issn.2096-9015.2020.0427

PDF( 786 KB)

An Instantaneous Flow Meter Module

doi: 10.12338/j.issn.2096-9015.2020.0427

FENG Jian,
ZHU Min

Guangdong Communication Polytechnic, Guangzhou 510800, China

Available Online: 2021-05-25
Publish Date: 2021-08-01

Abstract

Abstract

The measurement of flow velocity is usually made by counting pulses occruing in a flow meter in a time interval. However, this method cannot meet the need for real-time monitoring of flow velocity. This paper proposes a design of a flow meter module, which realizes instantaneous flow-velocity detection. The module includes circuits for signal processing, instantaneous velocity detection, and flow detection and a 485 interface. A test platform was built to verify the design. The relationship between the rotational speed of the flow sensor and the original output signal and the relationship between the pulse width and the signal frequency of the flow sensor were investigated. An MCU was used to upload the pulse width to a server to monitor the flow velocity in real time. Experiments showed that the module can detect flow signals with frequencies below 510 Hz in real time, with an error rate of pulse detection less than10⁻⁶.
- flow meter,
- instantaneous flow rate,
- signal processing,
- flow detection,
- 485 interface,
- real-time monitoring

FullText(HTML)

References(15)

References

[1]	张振. 基于DSP的高频励磁电磁流量变送器硬件研制[D]. 合肥: 合肥工业大学, 2013.
[2]	唐慧强, 佘艳, 唐明军. 基于MCS1211的电磁流量计的硬件设计[J]. 仪表技术与传感器, 2007, 44(12): 50-53.
[3]	朱小会, 袁玉霞, 吴紫君. 基于ARM的热式空气流量计的设计[J]. 仪表技术与传感器, 2019, 56(10): 54-56.
[4]	赵伟国, 徐晓丹, 章圣意. 大量程气体流量传感器的仿真与设计[J]. 传感技术学报, 2019, 32(7): 973-978.
[5]	刘林阴, 徐永安. 基于DSP的高频励磁电磁流量计设计[J]. 仪表技术与传感器, 2019, 56(8): 40-43.
[6]	葛健炎, 丁煜. 基于STM32和FPGA的超声波气体流量计[J]. 仪表技术与传感器, 2020, 57(10): 29-32.
[7]	李学明. 热式气体流量计的研究与应用[J]. 仪器仪表用户, 2020, 27(11): 99-101.
[8]	王浩. 超声波流量计工作原理及减小计量误差方法[J]. 科学技术创新, 2020, 24(28): 33-35.
[9]	高飞. 超声波流量计诊断技术在天然气计量中的应用[J]. 石油化工自动化, 2020, 56(5): 64-67.
[10]	张柯, 陈飞. 电磁流量计不同信号输出差异浅析[J]. 计量与测试技术, 2020, 47(7): 54-56.
[11]	杨丽娟. 电磁流量计测量误差原因及处理策略[J]. 中国设备工程, 2019, 35(22): 229-230.
[12]	窦华, 吴辉, 李月童, 等. 电磁流量计在线校准的可靠性分析[J]. 现代工业经济和信息化, 2020, 10(8): 82-83.
[13]	胡芸华, 刘勋, 李涛涛等. 基于MEMS流量传感器的智能燃气表[J]. 自动化技术与应用, 2019, 39(2): 116-118.
[14]	王振. 涡轮流量传感器在不同流体条件下测量性能的研究[D]. 天津: 天津大学, 2008.
[15]	马亚玲. 基于RS-485总线的MODBUS通信协议在单片机上的实现[J]. 通信电源技术, 2019, 36(7): 60-62.